OWNER’S MANUAL & OPERATING INSTRUCTIONS10006 Santa Fe Springs RoadSanta Fe Springs CA 90670USA / 1-877-338-0999www.championpowerequipment.comSAVE
7 REV 93520-20130425ENGLISH 93520CONTROLS AND FEATURESRead this owner’s manual before operating your log splitter. Familiarize yourself with the loca
REV 93520-20130425 893520 ENGLISHASSEMBLYYour log splitter requires some assembly.If you have any questions regarding the assembly of your log splitt
9 REV 93520-20130425ENGLISH 93520ASSEMBLY4) Install the Tow Bar Cont’d.3. Install the front support leg and secure with pin and R-pin (hairpin clip)
REV 93520-20130425 1093520 ENGLISHASSEMBLY6) Install the Cylinder and Wedge Cont’d.B7) Install the Engine and Hoses Cont’d.The pump outlet connection
11 REV 93520-20130425ENGLISH 93520ASSEMBLY6. Start Engine. Extend and retract the wedge to purge air from the hydraulic system. When the wedge motio
REV 93520-20130425 1293520 ENGLISHASSEMBLYThe engine is equipped with a low oil shut-off and will stop when the oil level in the crankcase falls belo
13 REV 93520-20130425ENGLISH 93520Add Fuel Cont’d.Add Fuel1. Use clean, fresh, regular unleaded fuel with a minimum octane rating of 85 and an ethan
REV 93520-20130425 1493520 ENGLISHOPERATIONBefore Each Use Inspect the Log Splitter1. Check the hydraulic oil level and visually inspect all hoses,
15 REV 93520-20130425ENGLISH 93520OPERATIONALWAYS use the log splitter for its intended use. The log splitter should only be used to split wood logs,
REV 93520-20130425 1693520 ENGLISHOPERATIONLog Splitter Operation1. ALWAYS wear ear and eye protection, protective clothing and safety gear.Log Spli
*We are always working to improve our products. Therefore, the enclosed product may differ slightly from the image on the cover.WARNING:The Engine Exh
17 REV 93520-20130425ENGLISH 93520OPERATIONOperation at High AltitudeThe density of air at high altitude is lower than at sea level. Engine power is
REV 93520-20130425 1893520 ENGLISHMAINTENANCE AND STORAGEThe owner/operator is responsible for all periodic maintenance.Complete all scheduled mainte
19 REV 93520-20130425ENGLISH 93520MAINTENANCE AND STORAGEAlways shut off the engine, disconnect the spark plug, and relieve system pressure before cl
REV 93520-20130425 2093520 ENGLISHMAINTENANCE AND STORAGEDO NOT use a garden hose to clean the engine or log splitter.CAUTIONWater can contaminate th
21 REV 93520-20130425ENGLISH 93520TROUBLESHOOTINGFor further technical support:Technical ServiceMon – Fri 8:30 AM – 5:00 PM (PST/PDT)Toll Free: 1-877
REV 93520-20130425 2293520 ENGLISHOilUse 10W-30 automotive oil.Oil capacity is 1.16 qt. (1.1 L).DO NOT OVERFILL.Please reference the following chart
23 REV 93520-20130425ENGLISH 93520Parts DiagramSPECIFICATIONS26 27 28291 2 35412116 9871016171918151314202518212223 24464039383745 23 2247 28 27 4875
REV 93520-20130425 2493520 ENGLISHParts List# Part Number Description Qty1PMJ35-02 Beam 12GB/T 889.1-2000 Lock Nut M12 83GB/T 95-2000 Washer 12 74PMJ
25 REV 93520-20130425ENGLISH 93520Engine Parts DiagramSPECIFICATIONS476413129130421201211221239212412510710810912611012712811111291113114115851323242
REV 93520-20130425 2693520 ENGLISHEngine Parts List# Part Number Description Qty121.061300.00 Recoil Handle 121.5789.0608 Flange bolt M6×8 3346.06110
93520TABLE OF CONTENTS35 TonLOG SPLITTERIntroduction ... 1Introduction ... 1Portable Log Splitter ...
27 REV 93520-20130425ENGLISH 93520WARRANTYWARRANTYCHAMPION POWER EQUIPMENT1 YEAR LIMITED WARRANTYWarranty QualificationsChampion Power Equipment (CPE)
Champion Power Equipment, Inc. (CPE), The United States Environment Protection Agency (U.S. EPA.) and the California Air Resources Board (CARB) Emiss
EMISSION CONTROL SYSTEM WARRANTY The following are specific provisions relative to your Emission Control System (ECS) Warranty Coverage. 1. APPLICA
EMISSION-RELATED PARTS INCLUDE THE FOLLOWING: (using those portions of the list applicable to the engine) Systems covered by this warranty Parts Des
1 REV 93520-20130425ENGLISH 93520INTRODUCTIONIntroductionCongratulations on your purchase of a Champion Power Equipment log splitter. CPE designs and
REV 93520-20130425 293520 ENGLISHMANUAL CONVENTIONSCAUTION indicates a potentially hazardous situation which, if not avoided, may result in minor or
3 REV 93520-20130425ENGLISH 93520SAFETY RULESLog Splitter engine exhaust contains carbon monoxide, a colorless, odorless, poison gas. Breathing carbo
REV 93520-20130425 493520 ENGLISHSAFETY RULESFuel and fuel vapors are highly flammable and extremely explosive. Fire or explosion can cause severe bur
5 REV 93520-20130425ENGLISH 93520Training1. Read the Operator’s Manual completely before attempting to use this log splitter.2. Do not allow anyone
REV 93520-20130425 693520 ENGLISHSAFETY RULESMaintenance and Storage1. Always shut off the power source while repairing or adjusting the splitter ex
Comments to this Manuals