Champion Power Equipment PORTAbLE GENERATOR Owner's Manual download pdf (Page 27)

REV 75537i-20140326 24

75537i ENGLISH

TROUBLESHOOTING

For further technical support:

Technical Service

Mon – Fri 8:30 AM – 5:00 PM (PST/PDT)

Toll Free: 1-877-338-0999

tech@championpowerequipment.com

Problem Cause Solution

Generator will not start No fuel Add fuel

Faulty spark plug Replace spark plug

Unit loaded during start up Remove load from unit

Generator will not start;

Generator starts but runs roughly

Low oil level Fill crankcase to the proper level

Place generator on a ﬂat, level surface

Choke in the wrong position Adjust choke

Spark plug wire loose Attach wire to spark plug

Generator will not start wirelessly Remote control battery is dead Replace remote control battery

Generator battery is dead Recharge generator battery

Battery switch is in the “OFF” position Turn battery switch to “ON” position

Generator will not start electrically Generator battery is dead Recharge generator battery

Battery switch is in the “OFF” position Turn battery switch to “ON” position

Generator shuts down during operation Out of fuel Fill fuel tank

Low oil level Fill crankcase to the proper level. Place

generator on a ﬂat, level surface

Generator cannot supply enough power or

overheating

Generator is overloaded Review load and adjust. See “Power

Management”

Insufﬁcient ventilation Check for air restriction. Move to a well

ventilated area

No AC output Cable not properly connected Check all connections

Connected device is defective Replace defective device

Circuit breaker is open Reset circuit breaker

Loose wiring Inspect and tighten wiring connections

Other Contact the help line

Repeated circuit breaker tripping Overload Review load and adjust. See “Power

Management”

Faulty cords or device Check for damaged, bare or frayed wires.

Replace defective device

1 2 ... 22 23 24 25 26 27 28 29 30 31

No comments

Champion Power Equipment PORTAbLE GENERATOR Owner's Manual Page 27